Study of Some Durability Properties of Self-compacting Concrete Containing Waste Polyethylene Terephthalate | ||
| Anbar Journal of Engineering Sciences | ||
| Article 3, Volume 14, Issue 1, May 2023, Pages 15-30 PDF (1.87 M) | ||
| Document Type: Research Paper | ||
| DOI: 10.37649/aengs.2023.137730.1035 | ||
| Authors | ||
| Marwah Majid* 1; Mahmoud K. Mohammed2 | ||
| 1civil engineering, university of Anbar, Ramadi | ||
| 2Department of Civil Engineering, College of Engineering, University Of Anbar. Ramadi, Anbar, Iraq | ||
| Abstract | ||
| This study aims to investigate the durability properties and microstructural changes of self-compacting concrete (SCC) incorporating waste polyethylene terephthalate (PET) as fibers and as fine aggregate replacement. This is after exposed to saline environment (Alkalies, Sulphates, and Chlorides). PET effect into two forms was also evaluated for routine rheological properties of SCC and mechanical strength before and after exposure to sulphate salt. Five proportions of each form of PET incorporation in SCC mixtures were utilized. The volume fractions considered for PET as fibers were (0.25, 0.5, 0.75, 1.0, and 1.25)% by volume, with aspect ratio of 28%, and (2, 4, 6, 8, and 10)% by volume for fine aggregate replacements. Results indicated that the inclusion of PET adversely affected fresh propertis especially high proportions of PET as fine aggregate. Alkali silica reaction (ASR) outcomes illustrated an enhancement in the mix containing PET fibers, while fine-PET mix was slightly enhanced. Magnesium sulphate reduced mass and compressive strength of all mixes in percentages ranging from (0.18-0.90) % for mass loss and from (0.47-55.13) % for compressive strength loss. Ultrasonic pulse velocity (UPV) and dynamic modulus of elasticity (Ed) increased due to the sulphate impact except for M0.5 and M10 which decreased in both tests. Chloride's theoretical and modelled results illustrated higher diffusion coefficients and lower surface chloride content of fiber-PET mixes as compared to fine-PET mixes. The predicted SCC cover depths for fiber-PET mixes were lower than those predicted for fine-PET mixes for 20 and 50 years of service life design. | ||
| Keywords | ||
| pet; SCC; Sulphate; ASR; Chloride | ||
| References | ||
|
[1] V. R. Sivakumar, O. R. Kavitha, G. Prince Arulraj, and V. G. Srisanthi, “An experimental study on combined effects of glass fiber and Metakaolin on the rheological, mechanical, and durability properties of self-compacting concrete,” Appl. Clay Sci., vol. 147, no. January, pp. 123–127, 2017, doi: 10.1016/j.clay.2017.07.015.
[2] S. Rasiah, “Properties of Flowing Concrete and Self-Compacting Concrete With High-Performance Superplasticier Properties of Flowing Concrete and Self-Compacting Concrete With High-Performance Superplasticier,” no. September, pp. 17–20, 2015.
[3] R. Dachowski and P. Kostrzewa, “The Use of Waste Materials in the Construction Industry,” Procedia Eng., vol. 161, pp. 754–758, 2016, doi: 10.1016/j.proeng.2016.08.764.
[4] B. Franco, A. M. Domingues, N. D. A. Africano, R. M. Deus, R. Aparecida, and G. Battistelle, “Sustainability in the Civil Construction Sector Supported by,” Infrastructures, vol. 7, no. 43, pp. 1–23, 2022.
[5] R. Sharma and P. P. Bansal, “Use of different forms of waste plastic in concrete - A review,” J. Clean. Prod., vol. 112, pp. 473–482, 2016, doi: 10.1016/j.jclepro.2015.08.042.
[6] A. I. Al-Hadithi and N. N. Hilal, “The possibility of enhancing some properties of self-compacting concrete by adding waste plastic fibers,” J. Build. Eng., vol. 8, pp. 20–28, 2016, doi: 10.1016/j.jobe.2016.06.011.
[7] P. Croce, P. Formichi, and F. Landi, “Climate change: Impacts on climatic actions and structural reliability,” Appl. Sci., vol. 9, no. 24, 2019, doi: 10.3390/app9245416.
[8] A. Colette, “Case studies on climate change and World Heritage ,” UNESCO World Heritage Centre, 2007.
[9] G. Giaccio, M. E. Bossio, M. C. Torrijos, and R. Zerbino, “Contribution of fiber reinforcement in concrete affected by alkali-silica reaction,” Cem. Concr. Res., vol. 67, pp. 310–317, 2015, doi: 10.1016/j.cemconres.2014.10.016.
[10] G. Giaccio, M. C. Torrijos, C. Milanesi, and R. Zerbino, “Alkali–silica reaction in plain and fibre concretes in field conditions,” Mater. Struct. Constr., vol. 52, no. 2, pp. 1–15, 2019, doi: 10.1617/s11527-019-1332-2.
[11] A. C. Bhogayata and N. K. Arora, “Impact strength, permeability and chemical resistance of concrete reinforced with metalized plastic waste fibers,” Constr. Build. Mater., vol. 161, pp. 254–266, 2018, doi: 10.1016/j.conbuildmat.2017.11.135.
[12] J. V. Marshall Raman, “Mechanical Studies of Self Compacting Concrete Using Plastic Aggregate,” Int. J. Res. Appl. Sci. Eng. Technol., vol. V, no. II, pp. 226–233, 2017, doi: 10.22214/ijraset.2017.2036.
[13] B. Preethiwini, S. Bharaniraja, M. Aravindhan, B. B. Pradeep, and R. Jothiprasath, “Comparative study on durability characteristics of high strength self compacting concrete,” Int. J. Civ. Eng. Technol., vol. 8, no. 3, pp. 942–949, 2017.
[14] G. S. Vijaya, V. G. Ghorpade, and H. Sudarsana Rao, “The Behaviour of Self Compacting Concrete with Waste Plastic Fibers When Subjected to Chloride Attack.,” Mater. Today Proc., vol. 5, no. 1, pp. 1501–1508, 2018, doi: 10.1016/j.matpr.2017.11.239.
[15] R. H. Faraj, A. F. H. Sherwani, and A. Daraei, “Mechanical, fracture and durability properties of self-compacting high strength concrete containing recycled polypropylene plastic particles,” J. Build. Eng., vol. 25, p. 100808, 2019, doi: 10.1016/j.jobe.2019.100808.
[16] Properties of Portland Cement, Iraqi Specification No.5, 2019.
[17] Natural Sources for aggregate that is used in concrete and construction, Iraqi Specification No.45, Baghdad, 1984.
[18] Standard Test Method for Relative Density (Specific Gravity) and Absorption of Fine Aggregate, ASTM C128-15, 2015.
[19] The European Guidelines for Self Compacting Concrete Specification, Production and Use, EFNARC, 2002.
[20] The European Guidelines for Self Compacting Concrete Specification, Production and Use, EFNARC, 2005.
[21] Standard Test Method for Potential Alkali Reactivity of Aggregates (Mortar-Bar Method), ASTM C1260-07, 2007.
[22] M.K. Mohammed "Multi-scale Response of Sustainable Self- Compacting Concrete ( SCC ) to Carbonation and Chloride Penetration" Ph.D. dissertation, Univ. of Nottingham ,” 2015.
[23] Concrete, hardened: accelerated chloride penetration, BUILD, Nord Test. 443, 1995.
[24] J. Jaskowska-Lemańska, M. Kucharska, J. Matuszak, P. Nowak, and W. Łukaszczyk, “Selected Properties of Self-Compacting Concrete with Recycled PET Aggregate,” Materials (Basel)., vol. 15, no. 7, 2022, doi: 10.3390/ma15072566.
[25] W. K. Aswatama, H. Suyoso, N. U. Meyfa, and P. Tedy, “The Effect of Adding PET (Polyethylen Terephthalate) Plastic Waste on SCC (Self-Compacting Concrete) to Fresh Concrete Behavior and Mechanical Characteristics,” J. Phys. Conf. Ser., vol. 953, no. 1, 2018, doi: 10.1088/1742-6596/953/1/012023.
[26] M. H. Mohammed “Production of SCC Using Local Waste Materials: Statistical Approach,” MSC thesis, Univ. Anbar, Coll. Eng., 2019.
[27] D. Bondar, C. J. Lynsdale, N. B. Milestone, and N. Hassani, “Sulfate Resistance of Alkali Activated Pozzolans,” Int. J. Concr. Struct. Mater., vol. 9, no. 2, pp. 145–158, 2015, doi: 10.1007/s40069-014-0093-0.
[28] H. Biricik, F. Aköz, F. Türker, and I. Berktay, “Resistance to magnesium sulfate and sodium sulfate attack of mortars containing wheat straw ash,” Cem. Concr. Res., vol. 30, no. 8, pp. 1189–1197, 2000, doi: 10.1016/S0008-8846(00)00314-8. | ||
|
Statistics Article View: 128 PDF Download: 97 |
||