Effect of Adding Recycled Sand and Fines Retained from Eggshell Waste on the Mechanical Properties and Durability of SCC and SFSCC | ||
| Engineering and Technology Journal | ||
| Article 3, Volume 41, Issue 5, May 2023, Pages 629-641 PDF (1.17 M) | ||
| Document Type: Research Paper | ||
| DOI: 10.30684/etj.2023.137162.1340 | ||
| Authors | ||
| Chaib. S* 1; Bensalem. R2 | ||
| 1Laboratoire de Mécanique des Sols et Structures. Université de Constantine. Algérie | ||
| 2Université des Frères Mentouri, Constantine1, Algeria. | ||
| Abstract | ||
| This scientific research was carried out within the framework of contributing to the recovery different of natures of waste, and making it possible to minimize using of natural aggregates in the field of construction, in order to place an eco-self-consolidating concrete (eco-SCC). Crushed demolition waste mainly of concrete had been studied as a substitute for natural sand. As well as the effect of replacing fines with crushed eggshell waste was assessed. So this present work fits in these contexts. Therefore the main objective of this study is to improve current knowledge on the behavior of studied concretes in the fresh state: slump-flow test, and hardened state: mechanical resistances in compression and in bending, as well as water absorption by capillarity test, absorption by total immersion, and porosity accessible to the water of SCCs designed from different types of waste, recycled sand, and eggshell fines. Also, the method of assessing mixes were affected by the sort of chemical attack, namely the (NaCl) attack was investigated. In light of the obtained results, it was found that the addition of eggshell fines in adequate quantity, can improve the properties of SCCs, in this study a volume of 30% was sufficient, increasing the volume added to 60% introduced an opposite effect. Using recycled sand in this study did not contribute to a significant effect on the mechanical properties of the mixtures studied, although an improvement in workability was observed. | ||
Highlights | ||
| ||
| Keywords | ||
| Self-consolidating concrete (SCC); Eggshell fines; Recycled sand; Steel Fibers; Fresh state; Mechanical characteristics; Durability | ||
| References | ||
|
[1] S. Chaib, R. Lassoued, Combined Effect of Low and High Rate of Corrugated Steel Fiber and Stirrups on Mechanical Performance of SFSCC Beams. Aceh Int. J. Sci. Technol. 10 (2021) 37-51.http://dx.doi.org/10.13170/aijst.10.1.19723 [2] PH. Turcry, Shrinkage and cracking of SCC: influence of the formulation, Ph.D. Thesis, University of Nantes Central School, University of Nantes, 2004. [3] M. Bouaziz., Reformulation of a SCC: influence of the (G/S) ratio and the date palm fiber of 30 mm in length, Ph.D. Thesis, University of Annaba, Algeria 2019 [4] R. Dupain and R. Lanchon : «Aggregates, soils, cement and concrete», Edition CASTEILLA-PARIS-2004. [5] M. Petitpain, S. Dehaudt, F. Jacquemot, P. Rougeau. Using alternative raw materials in concrete. Annals of Building and Public Works, Editions ESKA.68 (2016)7. [6] http://fr.wikipedia.org/wiki/Concrete recycling. [7] National Waste Agency (AND), 2019, characterization manual how to succeed in a characterization campaign for household and similar waste – DMA, pages 5 and 8, 2019 [8] N. Bourmatte, Substitute Recycled Aggregates for Hydraulic Concrete, Characterization, Performance, Durability, Magister Thesis, University of Constantine, Algeria, 2005. [9] E. Benammar, Valorization of table eggshells, as a calcium supplement, in the diet of laying hens: Effects on egg quality, Ph.D. Thesis, University of Akli Mohand Oulhadj – Bouira, Algeria, 2019. [10] H. Binici, O. Aksogan, A. H. Sevinc, E. Cinpolat. Mechanical and radio activity shielding performances of mortars made with cement, sand and eggshells. Constr Build Mater. 93 (2015) 1145–1150. https://doi.org/10.1016/j.conbuildmat.2015.05.020 [11] A. Hadjira. Study of the properties of a new made polypropylene loaded with eggshell, Ph.D. Thesis, University of Boumerdas, Algeria, 2017. [12] U. N. Okonkwo, I. C. Odiong, and E. E. Akpabio, The effects of egg shell ash on strength properties of cement-stabilized lateritic. International Journal of Sustainable Construction Engineering &Technology (IJSCET). 3 (2012)18–25. [13] J. Karthick, R. Jeyanthi, M. Petchiyammal, Experimental Study on Usage of Egg Shell as Partial Replacement for Sand in Concrete. International Journal of Advanced Research in Education Technology. 1 (2014). [14] I. DohS. The Performance of Eggshell as Filler in Concrete Mixtures. Proceedings of the 2014 International Conference on Industrial Engineering and Operations Management Bali, Indonesia, 2014. [15] S.A. Raji, A. T. Samuel, Egg Shell as a Fine Aggregate in Concrete for Sustainable Construction. Int. J. Sci .Technol Res. 4 (2015) 8-13. [16] N. Sathiparan, Utilization prospects of egg shell powder in sustainable construction material a review Author: Publication: Construction and Building Materials Publisher: Elsevier Date: 26 July 2021. [17] M Sivakumar ., and N. Mahendran, Strength and Permeability Properties of Concrete Using Fly Ash (FA), Rise Husk Ash (RHA) And Egg Shell Powder (ESP). Journal of Theoretical and Applied Information Technology 20th August. 66 (2014) 489-499 [18] M. S. De Juan, P. A. Gutierrez, Study on the influence of attached mortar content on the properties of recycled concrete aggregate. Constr. Build. Mater. 23 (2019) 872-7. https://doi.org/10.1016/j.conbuildmat.2008.04.012 [19] G. Arquie, C.Tourenq, "Aggregates", Presses of the National School of Bridges and Roads, 717 p., 1990. [20] Y. Fritih. Contribution of fiber reinforcement to the behavior of reinforced self-compacting concrete elements, Ph.D. Thesis, University of Toulouse, Research unit: Materials and Durability of Constructions Laboratory. 2009. [21] J. Ashly and S. Sreerat. Experimental Investigation on Fresh and Hardened Properties of Hybrid Fiber-Reinforced Self-Compacting Concrete. 46 (2020) 831–840. https://doi.org/10.1007/978-3-030-26365-2_76 | ||
|
Statistics Article View: 169 PDF Download: 244 |
||