Studying the Factors effect on Separation of Two Solid Equivalent Particle According to Density and Determination the best Separation Point | ||
Anbar Journal of Engineering Sciences | ||
Article 3, Volume 13, Issue 2, November 2022, Pages 22-35 PDF (1 M) | ||
Document Type: Research Paper | ||
DOI: 10.37649/aengs.2022.176354 | ||
Author | ||
Suha Mahdi Salih* | ||
Department of Chemical Engineering, College of Engineering, University of Anbar, Ramadi 310011, Iraq | ||
Abstract | ||
Density separation has many applications in metallurgy, medicine, clinical chemistry, microbiology, and agriculture. This study investigates the factors' effects on density separation in order to benefit from this technique. The separation quality depends on the velocity of particles because as the velocity of particles increases, the mean separation needs less time so it gives better separation, so the parameter effect on the value of the velocity is studied. These parameters were volume fractions, the diameter of the sphere, the density of the sphere, and the viscosity of the fluid. Each parameter was studied by calculating the velocity of particles using Stokes' law. The velocity of particles is directly proportional to some properties of particles. These properties are the diameter and density of a particle because as these properties increase, the mass of particles increases, which leads to increased kinetic energy, which increases turbulence. Turblance's velocity is increasing. The volume fraction of spheres is another property of particles' effects on density separation. This parameter is inversely proportional to velocity because a collision between particles increases, which decreases turbulence. Fluid properties also have an impact on density separation. This property is viscosity. Its effect deteriorates the efficiency of separation because viscosity is the resistance of the fluid to flow that serves to displace the particle, which leads to a reduction in the velocity of the particle. The maximum separation happens when the sink and float particles separate at the same time. That happens when the sink and float particles have the same velocity in the opposite direction. That means when the sum of velocities equals zero. In this research, the maximum separation was derived when the sum of velocities equaled zero. | ||
Keywords | ||
Density; density separation; sink and float particle | ||
References | ||
[1] Koroznikova L., Klutke C., McKnight S., Hall S. (2008) The use of low-toxic heavy suspensions in mineral sands evaluation and zircon fractionation. The Journal of The Southern African Institute of Mining and Metallurgy, 108, 25-33
[2] Cresswell, G.M., 2001, July. Pre-concentration of base metal ores by dense medium separation. In SAIMM cooper, cobalt, nickel and zinc recovery conference (pp. 1-10).
[3] Vitz E, John W.Moore, Justin Shorb ,Adam Hahn ,2006 “Sorting Recyclable Plastics By density”Chemical & amp,Engineering News,March.No16, p,30-33
[4] Kumar CR, Mohanan S, Tripathy SK, Ramamurthy Y., Venugopalan T, Nikkam S (2011) “Prediction of process input interactions of Floatex Density Separator performance for separating medium density particles” International Journal of Mineral Processing, 100 136-141
[5] Gluskoter, H. J. (1977). Trace elements in coal: occurrence and distribution. Circular no. 499.
[6] Quinn, B., Murphy, F. and Ewins, C., 2017. Validation of density separation for the rapid recovery of microplastics from sediment. Analytical Methods, 9(9), pp.1491-1498.
[7] Klima, M. S., & Kim, B. H. (1996). The separation of fine, high density particles from a low‐density soil matrix using a hydrocvclone. Journal of Environmental Science & Health Part A, 31(2), 305-323.
[8] J.S.Haskill, R.D. Mcknight and P.R.Galbraith , 1972, Cell-Cell Interaction in Vitro: Studied by Density Separation of Colony-forming, Stimulating, and Inhibiting Cells From Human Bone Marrow,Blood Journal,40.:394-399
[9] A.W. Hamburger, F.E. Dunn, and C.P. White, 1985 "Percoll density gradient separation of cells from human malignant effusions",British Journal of Cancer, 51(2):253-258.
[10] V.N.de Jonge & L.A. Bouwman 1977 " A simple density separation technique for quantitative isolation of meiobenthos using the colloidal silica Ludox-TM ,Marine Biology 42 (2), 143-148
[11] Robert S.Strebin JR.,John W.Johson and Dean M.Robertson , 1977 "Wide-range density separation of mineral particles in a single fluid system" American Mineralogist, Volume62, pages 374-376
[12] Kumar CR, Singh RR, Venugopalan OK, Murty VS, Kumar SS 2006 " Effect of Teetering Pulp Density in Floatex Density Separator A_Case Study", Proceedings of the International Seminar on MineralProcessing Technology - , Chennai, India. pp. 564
[13] Kohl C.P and Nishiizumi K, 1992"chemical isolation of quartz for measurement of in-situ-produced cosmogenic nuclides "Cosmochimica Acta,56,3583-3587.
[14] G.Halam .1969 "separation of clay mineral fractions with linear heavy liquid density gradient columns"department of regional soil science,Agricultural university ,Wagentingen,Holland clay minerals8,59
[15] Pactrick S, Reid J.H.1983. Separation of capsulate and non-capsulate Bactroids Fragilis on a discontinuous density gradient. Journal of Medical Microbiology, 16, 239-241.
[16] Laursen SB, Andersen CY, Hindkjaer J, Karin ERB, 2003 .A clinical study comparing pure sperm and sperm filter for density gradient separation of human spermatozoa in assisted reproduction. Acta Obstet Gynecol Scand, 82. 929-935.
[17] Hans ULutz,..et al. (1992) .Density separation of human red blood cells on self forming Percoll gradients: correlation with cell age", Biochimica et Biophysica Acta (BBA)-General Subjects 1116 (1), 1-10.
[18] Rockne KJ, Liang W, Young L.Y., Taghon GL (2003) .Toxicity of density separation media to Escherichia coli and Mycobacterium strain PC01:implications for density-separation of soils and sediments" FEMS Microbiology Ecology, 43, 185-189
[19] Alopes-Virella MF, Stone P, Ellis S, Colwell JA. (1977) .Cholesterol Determination in High-Density Lipoproteins separated by three Different Methods"Clinical chemistry,vol-23,NO.5, 882-884
[20] Taylor, A.G.; Kenny, T.J. (1985) "Improvement of germinated seed quality by density separation".Journal of American Horticultural Science, v.110, 347-349.
[21] Takaki M, Lima GPP. 2008 .Density separation of germinated seeds of melaleuca leucadendra(L.)L.(myrtaceae)" Naturalia, Rio Claro, v.31, p.34-38
[22] Jordão, L.R.; Lopes, V.B.; Takaki, M. 1988 "Selection of viable seeds in Hormidium coriaceum Lindl. (Orchidaceae) by density separation." Seed Science and Technology, v.16,p.515-519.
[23] Taylor, A.G.; Motes, J.E.; Price, H.C." 1978” Separating germinated from ungerminated seed by specific gravity". HorScience, v.13, p.481-482.
[24] Zimmels Y. (1985) .Theory of density separation of particulate system. Powder technology, 43127-139.
[25] Kawanisi K and Shiozaki R 2008. Turbulent Effects on the Settling Velocity of Suspended Sediment “Journal of Hydraulic Engineering Volume 134 Issue 2 - February
[26] Eames, I.; Flor, J. B. January 17, (2011). New developments in understanding interfacial processes in turbulent flows". Philosophical Transactions of the Royal Society A. 369: 702–705.
[27] T. Ogholaja, D.O njouenbwu and M. Fairweather, 2018”LES of particle collision and agglomeration in vertical channel flows” Computer Aided Chemical Engineering, 2018
[28] Y. Wang, K. M. Lam, and Y. Lu,2018”Settling velocity of fine heavy particles in turbulent open channel flow”Physics of Fluids 30, 095106
[29] Henry Watts,Matthew Moncrieff Pattison Muir,Henry Forster Morley • 1890,Watts' Dictionary of Chemistry - Volume 1 - Page 90
[30] Dabir S. V, Tushar K. Ghosh, Dasika H. L. Prasad, Nidamarty V.K. Dutt and Kalipatnapu Y. Rani 2007 “viscosity of liquid “Indian Institute of Chemical Technology, Hyderabad, India,Pages 1-8. | ||
Statistics Article View: 908 PDF Download: 133 |