Optimization Process for Biodiesel Production From Waste Cooking of Vegetable Oil by Microwave Irradiation

Ibrahim, Raheek I.; Reja, Ahmed H.; Kadhim, Abeer J.

doi:10.30684/etj.v40i1.1981

Journals List

Optimization Process for Biodiesel Production From Waste Cooking of Vegetable Oil by Microwave Irradiation

Engineering and Technology Journal

Article 6, Volume 40, Issue 1, January 2022, Pages 49-59 PDF (867.88 K)

Document Type: Research Paper

DOI: 10.30684/etj.v40i1.1981

Authors

Raheek I. Ibrahim^* ; Ahmed H. Reja; Abeer J. Kadhim

Department of Electromechanical Engineering, University of Technology, Baghdad, Iraq.

Abstract

Biodiesel is the main alternative to diesel fuel today. The waste cooking vegetable oil can be used as a basic material in its preparation. Microwave irradiation is used in its production and it is considered one of the effective methods that do not consume much power. In this study, biodiesel is produce and determine the factors affecting the quality and quantity of production also investigated using experimental design technique. The effecting of operating variables power, time, and oil-to-ethanol molar ratio were studied, as well as the effect of interaction between operating variables on the quality of production. The optimum conditions that have been found are; the power that the microwave operates is 480 watts, the reaction time is 3.5 minutes, and the oil-to-ethanol molar ratio is 1:5. The maximum production is 91.63% at these optimum conditions. Also, the biodiesel production is testing which include physical properties specific gravity, kinematic viscosity, water content, cloud point, pour point, and flash point and it was in good agreement with standard diesel fuel.

Highlights

· The using of microwave oven technology with a multiple power source range in the process of producing biodiesel from waste cooking vegetable oil.

· One of the most important findings of a study is use of ethanol which is a renewable source of production instead of methanol as in other studies.

Biodiesel was produced from waste cooking vegetable oil that can be used as an alternative to regular fuel and thus it is considered clean renewable energy,subject to recycling processes and environmentally friendly.

· The using of microwave oven technology with a multiple power source range in the process of producing biodiesel from waste cooking vegetable oil.

· One of the most important findings of a study is use of ethanol which is a renewable source of production instead of methanol as in other studies.

· Biodiesel was produced from waste cooking vegetable oil that can be used as an alternative to regular fuel and thus it is considered clean renewable energy,subject to recycling processes and environmentally friendly.

Keywords

Biodiesel; Waste cooking vegetable oil; Microwave irradiation

References

[1] Arshad, M., Bano, I., Khan, N., Shahzad, M. I., Younus, M., Abbas, M., & Iqbal, M. Electricity generation from biogas of poultry waste: An assessment of potential and feasibility in Pakistan. Renewable and Sustainable Energy Reviews, 81,2018, 1241–1246. doi:10.1016/j.rser.2017.09.007

[2] Canesin, E. A., & Oliveria, C. C. Characterization of residual oils for biodiesel production. Electronic Journal of Biotechnology, 17,2014, 39–45.

[3] Asri & Sari,2015; Asri, Sari, Poedjojono, & Suprapto, 2015; Haigh, Abidin, Saha, &Vladisavljević, 2012; Hiwot, 2017; Noiroj, Intarapong, Luengnaruemitchai, & Jai-In, 2009; Saifuddin, Raziah, & Farah, 2009;Omar, Nordin, Mohamed, & Amin, 2009; Wang, Ou, Liu, Xue, & Tang,2006.

[4] Refaat, A. A. Different techniques for the production of biodiesel from waste vegetable oil. International Journal of Environmental Science & Technology, 7,1, 2,2010,183-213.

[5] Dorado, M.P., Ballesteros, E., López, F. J. and Mittelbach, M. Optimization of alkali-catalyzed transesterification of Brassica carinata oil for biodiesel production. Energ. Fuel, 18,1,2004,77-83.

[6] Lin, Y.C., Hsu, K.H. and Chen, C.B. Experimental investigation of the performance and emissions of a heavy-duty diesel engine fueled with waste cooking oil biodiesel/ultra-low sulfur diesel blends. Energy, 36,1,2011,241-248.

[7] Carlos, A., Guerrero, F., Guerrero-Romero, A., & Sierra, F. E. Biodiesel Production from Waste Cooking Oil, Biodiesel-Feedstocks and Processing Technologies. National University of Colombia, Colombia, 2011-2015.

[8] Firoz, S. A review: advantages and disadvantages of biodiesel. International Research Journal of Engineering and Technology, 4,11,2017,530-533.

[9] Zhou, W.; Boocock, D. G. V., Ethyl esters from the single-phase base-catalyzed ethanolysis of vegetable oils.,J. Am. Oil Chem. Soc., 80 ,4,2003, 367-371.

[10] Saifuddin, N.; Chua, K. H., Production of ethyl ester (biodiesel) from used frying oil, Optimization of transesterification process using microwave irradiation.,Malaysian J. Chem., 6 ,1, 2004,77- 82.

[11] Encinar, J. M.; Juan, F.; Gonzalez, J. F.; Rodriguez-Reinares, A., Ethanolysis of used frying oils: Biodiesel preparation and Characterization. Fuel Process. Tech., 88,5,2007, 513-522.

[12] Refaat, A. A., Attia, N. K., Sibak, H. A., El Sheltawy, S. T., & ElDiwani, G. I. Production optimization and quality assessment of biodiesel from waste vegetable oil. International Journal of Environmental Science & Technology, 5,1, 2008,75-82.

[13] Zhou, W.; Boocock, D. G. B., Phase behavior of the base-catalyzed transesterification of soybean oil. J. Am. Oil Chem. Soc., 83 ,12, 2006,1041-1045 .

[14] Singh, A.; He, B.; Thompson, J.; van Gerpen, J., Process optimization of biodiesel production using different alkaline catalysts. Appl. Eng. Agr., 22 , 4 ,2006, 597-600.

[15] Tomasevic, A. V.; Siler-Marinkovic, S. S., Methanolysis of used frying oil. Fuel Process Tech., 81,1, 2003,1-6.

[16] Saifuddin, N.; Chua, K. H., Production of ethyl ester (Biodiesel) from used frying oil: Optimization of transesterification process using microwave irradiation. Malays. J. Chem., 6 , 1,2004,77- 82.

[17] Felizardo, P.; Correia, M. J.; Raposo, I.; Mendes, J. F.; Berkemeier, R.; Bordado J. M., Production of biodiesel from waste frying oils. Waste Manage., 26 ,5,2006,487-494.

[18] Dorado, M. P.; Ballesteros, E.; Mittelbach, M.; Lopez, F. J., Kinetic parameters affecting the alkali-catalyzed transesterification process of used olive oil. Energ. Fuel.,18 ,5,2004, 1457-1462.

[19] Chhetri, A. B.; Watts, K. C.; Islam, M. R., Waste cooking oil as an alternate feedstock for biodiesel production. Energies, 1 ,1,2008,3-18.

[20] Demirbas, A., Biodiesel from waste cooking oil via base-catalytic and supercritical methanol transesterification. Energ. Convers. Manage., 50 ,4,2009, 923- 927.

[21] Khatun, M. S., Khatun, M. A., Khan, M. Z. H., & Debnath, M. Methyl ester (biodesel) production from waste cooking vegetable oil by microwave irradiation. Malaysian Journal of Analytical Sciences, 18,2,2014, 321-328.

[22] Priambodo, R., Chen, T. C., Lu, M. C., Gedanken, A., Liao, J. D., & Huang, Y. H. Novel technology for bio-diesel production from cooking and waste cooking oil by microwave irradiation. Energy Procedia, 75,2015, 84-91.‏

[23] Fadhil, A. B., Al-Tikrity, E. T., & Albadree, M. A. Biodiesel production from mixed non-edible oils, castor seed oil and waste fish oil. Fuel, 210,2017, 721-728.‏

[24] Fadhil, A. B., Nayyef, A. W., & Sedeeq, S. H. Valorization of mixed radish seed oil and Prunus armeniaca L. oil as a promising feedstock for biodiesel production: evaluation and analysis of biodiesels. Asia‐Pacific Journal of Chemical Engineering, 15,1,2020, e2390.‏

[25] Refaat, A. A., Attia, N. K., Sibak, H. A., El Sheltawy, S. T., & ElDiwani, G. I. Production optimization and quality assessment of biodiesel from waste vegetable oil. International Journal of Environmental Science & Technology, 5,1,2008, 75-82.‏

[26] Petrović, Srdjan, et al. Optimization of a nanoparticle ball milling process parameters using the response surface method. Advanced Powder Technology 29,9 ,2018, 2129-2139

[27] Amna, M., Mustafa, Design and implementation of an electromechanical system for treatment of dynamic turbulaence within the flow of heavy fluids.,M.Sc. Thesis University of Technology, Electromechanical Engineering Department 2018.

[28] Mansourpoor, M., and A. Shariati. Optimization of biodiesel production from sunflower oil using response surface methodology. J Chem Eng Process Technol 3,5 ,2012.‏

[29] Morshed, M., Ferdous, K., Khan, M. and Mazumder, R. Rubber seed oil as a potential source for biodiesel production in Bangladesh. Fuel, 90,2011, 2981-2986.

[30] Joshi, R.M., Pegg, M. J. Flow properties of biodiesel fuel blends at low temperatures. Fuel, 86,2007, 143-151.

[31] Aboelazayem, O., Gadalla, M., & Saha, B. Biodiesel production from waste cooking oil via supercritical methanol: Optimisation and reactor simulation. Renewable Energy, 124,2018, 144-154.‏

Statistics

Article View: 328

PDF Download: 314