Characteristics of Exhaust Emissions for a Diesel Engine Fuelled by Corn Oil Biodiesel and Blended with Diesel Fuel | ||
| Engineering and Technology Journal | ||
| Article 19, Volume 38, 3A, March 2020, Pages 457-464 PDF (429.58 K) | ||
| DOI: 10.30684/etj.v38i3A.446 | ||
| Authors | ||
| Abdulrahman S. Mahmood* 1; Haqi I. Qatta2; Saadi M.D. Al-Nuzal* 1; Talib K. Abed1 | ||
| 1Environmental Research Center, University of Technology, Baghdad, Iraq | ||
| 2Nanotechnology and Advanced Materials Research Center, University of Technology, Baghdad, Iraq | ||
| Abstract | ||
| Environmentally friend biodiesel fuel from corn oil was tested in single-cylinder 4-stroke diesel engine operated. Three blends of fuels were prepared from corn oil and diesel fuel viz. 7, 15, and 20 % (designated as B7, B15, and B20, respectively). Tests were conducted on this engine using these blends at a constant speed (1500 rpm) and varying loads (0 % to 100 %). The emissions of carbon monoxide, carbon dioxide, unburned hydrocarbons, nitrogen oxides (NOX) and smoke opacity were measured. In all engine loads, results showed that the emission of CO, HC, and smoke emissions were reduced, while that of NOX and CO2 were increased. Biodiesel blend (B20) showed the highest decrease of the CO and HC and smoke emissions by 22.13 %, 18.5 %, and 25.8 % respectively. While that of NOX and CO2 emissions were increased by 22.3 % and 22%, respectively. It can be recommended as a sound environment friend and renewable for use in diesel engines and can be used without any significant modifications in the engine design | ||
| Keywords | ||
| Environmentally friend biodiesel fuel; Diesel Engine; Corn oil, Emission gases; Fuel Blend | ||
| References | ||
|
[1] M. R. Seifi, S. R. Hassan-Beygi, B. Ghobadian, U. Desideri, and M. Antonelli, “Experimental investigation of a diesel engine power, torque and noise emission using water–diesel emulsions,” Fuel, Vol. 166, pp.392-399, 2016. [2] A. Sharma, N. Kumar, V. Vibhanshu, and A. Deep, “Emission studies on a VCR engine using stable diesel water emulsion,” SAE Technical Paper; SAE International: Warren dale, WA, USA, (No. 2013-01-266, 2013. [3] I. A. Resitoglu, K. Altinişik, and A. Keskin, “The pollutant emissions from diesel-engine vehicles and exhaust after treatment systems,” Clean Technologies and Environmental Policy, Vol. 17, No. 1, pp. 15-27, 2015. [4] F. Martins, C. Felgueiras, M. Smitkova, and N. Caetano, “Analysis of fossil fuel energy consumption and environmental impacts in European countries,” Energies, Vol. 12, No. 6, pp. 964, 2019. [5] A. Mahalingam, D. B. Munuswamy, Y. Devarajan, and S. Radhakrishnan, “Emission and performance analysis on the effect of exhaust gas recirculation in alcohol-biodiesel aspirated research diesel engine,” Environmental Science and Pollution Research, Vol. 25, No. 13, pp. 12641–12647, 2018. [6] M. Singh, S. K. Gandhi, S. K. Mahla, and S. S. Sandhu, “Experimental investigations on performance and emission characteristics of variable speed multi-cylinder compression ignition engine using diesel/ argemone biodiesel blends,” Energy Exploration and Exploitation, Vol. 36, No. 3, pp. 535-555, 2018. [7] S. Dharma, H. H. Masjuki, H. C. Ong, H. C., Sebayang, A. H., Silitonga, A. S., Kusumo, F., and T. M. I. Mahlia, “Optimization of biodiesel production process for mixed jatropha curcas – ceiba pentandra biodiesel using response surface methodology,” Energy Conversion and Management, Vol. 115, pp. 178-190, 2016. [8] C. M. Noor, M. M. Noor, and R. Mamat, “Biodiesel as alternative fuel for marine diesel engine applications: a review,” renewable and sustainable energy reviews, Vol. 94, pp. 127-142, 2018. [9] E. Alptekin, M. Canakci, and H. Sanli, “Biodiesel production from vegetable oil and waste animal fats in a pilot plant,” Waste Management, Vol. 34, No. 11, pp. 2146-2154, 2014. [10] H. K. Imdadul, H. H. Masjuki, Kalam, Zulkifli, N. W.M., Rashed, M. M., Rashedul, H. K., Monirul, I.M. and M. H. Mosarof, “A Comprehensive review on the assessment of fuel additive effects on combustion behavior in ci engine fuelled with diesel biodiesel blends,” RSC Advances, Vol. 5, No. 83, pp. 67541-67567, 2015. [11] S. Grebemariam, and J. M. Marchetti, “Biodiesel production technologies,” AIMS Energy, Vol. 5, No. 3, pp. 425-457, 2017. [12] Udayakumar, R., and Khurana, S., “Experimental investigations on emissions characteristics of a variable compression ratio engine operated on dual fuel mode using diesel and biodiesel (obtained from cotton seed oil and rice bran oil),” Journal of Mechanical Engineering Research and Developments (JMERD), Vol. 41, No. 3, pp. 59-66, 2018. [13] O. M. Ali, R. Mamat, N. R. Abdullah, and A. A. Abdullah, “Analysis of blended fuel properties and engine performance with palm biodiesel–diesel blended fuel,” Renewable Energy, Vol. 86, pp. 59-67, 2016. [14] L. A. Raman, B. Deepanraj, S. Rajakumar, and V. Sivasubramanian, “Experimental investigation on performance, combustion and emission analysis of a direct injection diesel engine fuelled with rapeseed oil biodiesel,” Fuel, Vol. 246, pp. 69-74, 2019. [15] M. S. Gad, R. El-Araby, K. A. Abed, N. N. El-Ibiari, A. K. El Morsi, and G. I. El-Diwani, “Performance and emissions characteristics of CI engine fueled with palm oil/palm oil methyl ester blended with diesel fuel,” Egyptian Journal of Petroleum, Vol. 27, No. 2, pp. 215-219, 2018. [16] K. A. Abed, A. K. El Morsi, M. M. Sayed, A. A. El Shaib, and M. S. Gad, “Effect of waste cooking-oil biodiesel on performance and exhaust emissions of a diesel engine,” Egyptian Journal of Petroleum, Vol. 27, No. 4, pp. 985-989, 2018. [17] B. Prbakaran, D. and Viswanathan, “Experimental investigation of effects of addition of ethanol to bio-diesel on performance, combustion and emission characteristics in CI engine,” Alexandria Engineering Journal, Vol. 57, No. 1, pp. 383-389, 2018. [18] M. Chhabra, A. Sharma, and G. Dwivedi, “Performance evaluation of diesel engine using rice bran biodiesel,” Egyptian Journal of Petroleum, Vol. 26, No. 2, pp. 511-518, 2017. [19] D. De Serio, A. de Oliveira, and J. R. Sodré, “Effects of EGR rate on performance and emissions of a diesel power generator fueled by B7,” Journal of the Brazilian Society of Mechanical Sciences and Engineering, Vol. 39, No. 6, pp. 1919-1927, 2017. [20] M. S. Imran, and H. J. Kurji, “The impact of using biodiesel prepared from waste sunflower oil and iraqi conventional diesel on compression ignition engine performance and emissions,” Journal of Mechanical Engineering Research and Developments (JMERD), Vol. 41, No. 3, pp. 32-37, 2018. [21] P. Dinesha, and P. Mohanan, “A study of the effect of injection mressure on the combustion, performance, and emission characteristics of cardanol biofuel blend fuelled compression ignition Engine,” Asia‐Pacific Journal of Chemical Engineering, Vol. 10, No. 1, pp. 56-64, 2015. [22] S. S. Satputaley, D. B. Zodpe, and N. V.Deshpande, “Performance, combustion, and emission study on CI engine using microalgae oil and microalgae oil methyl esters,” Journal of the Energy Institute, Vol. 90, No. 4, pp. 513-521, 2017. [23] A. Killol, N. Reddy, S. Paruvada, and S. Murugan, “Experimental studies of a diesel engine run on biodiesel n-butanol blends,” Renewable Energy, Vol. 135, pp. 687-700, 2019. [24] M. K. Yesilyurt, “The effects of the fuel injection pressure on the performance and emission characteristics of a diesel engine fuelled with waste cooking oil biodiesel-diesel blends,” Renewable energy, Vol. 132, pp. 649-666, 2019. [25] M. Yadav, S. B. Chavan, R. Singh, F. Bux, and Y. C. Sharma, “Experimental study on emissions of algal biodiesel and its blends on a diesel engine,” Journal of the Taiwan Institute of Chemical Engineers, Vol. 96, pp.160-168, 2019 | ||
|
Statistics Article View: 242 PDF Download: 239 |
||